Concorde RG-224 excels in long range operations

September 03, 2013
concorde_battery_rg-224_hr
 
   
Sept. 3, 2013, - Concorde designed the RG-224, 24 Ah, RG® Series (recombinant gas) helicopter battery to fulfill a demand for a higher capacity battery on the Bell LongRanger and has received an overwhelming amount of positive feedback. Numerous LongRanger operators have converted to the RG-224, using Falcon Crest’s STC SR09069RC, to reduce engine wear and increase battery life.

High cyclic operations are hard on aircraft batteries due to frequent starts with short flight times. This style of operation shortens battery life because there is not enough time in flight for the battery to fully recharge. The two consequences of a partial charge are decreased capacity and shortened battery life.

When a battery is not fully recharged sulfate builds on battery plates. The sections of the plates covered with sulphate are inactive and the battery is unable to provide full cranking capacity on the next demanding start cycle. This decrease in capacity causes unnecessary wear on engine components. Air Ambulance and Oil & Gas fleets experience some of the highest cyclic operations. These operators have responded with surprise at the increased starting power and improved performance experienced after upgrading to the RG-224 packed with 42% more power than RG-
222.

Aircraft batteries can be damaged beyond repair when they are discharged below 80% of their capacity. In high cyclic operations the capacity is slightly drained a little more on each start because a full charge is never achieved during a short flight. The higher capacity RG-224 provides
more room for discharge before a full charge is required thereby extending battery life. To extend your battery life and prevent unnecessary wear upgrade to Concorde’s RG-224 in your LongRanger using Falcon Crest STC SR09069RC.

Add comment


Security code
Refresh

Subscription Centre

 
New Subscription
 
Already a Subscriber
 
Customer Service
 
View Digital Magazine Renew

Most Popular

Latest Events

HAI Heli-Expo
February 26-1, 2018
MRO Americas 2018
April 10-12, 2018
CANSEC 2018
May 30, 2018